In this paper, a series of bio-based epoxy resins containing organic silicone were prepared from eugenol through a mild synthetic route. Then, 4,4′-diaminophenyl methane (DDM) was applied to cure these epoxy resins, and bisphenol A epoxy resin (DGEBA) was used as a control. The chemical structures of the synthesized resins were characterized by nuclear magnetic resonance (1H-NMR). Properties of the cured epoxy resins were investigated by dielectric test, differential scanning calorimetry (DSC), thermogravimetric analysis (TGA), dynamic mechanical analysis (DMA), and scanning electron microscopy (SEM). Compared with DGEBA, the bio-based epoxy resin containing cyclic organic silicon structure exhibited a dramatically lower dielectric constant at both low and high frequencies (3.46, 1 kHz, room temperature). Moreover, the silicone-modified bio-based epoxy resins demonstrated no weight loss below 325 °C and higher residues at 800 °C than that of DGEBA.
Issue Section:
Research Papers
References
1.
Auvergne
, R.
, Caillol
, S.
, David
, G.
, Boutevin
, B.
, and Pascault
, J. P.
, 2014
, “Biobased Thermosetting Epoxy: Present and Future
,” Chem. Rev.
, 114
(2
), pp. 1082
–1115
.2.
Jin
, F. L.
, Li
, X.
, and Park
, S. J.
, 2015
, “Synthesis and Application of Epoxy Resins: A Review
,” J. Ind. Eng. Chem.
, 29
, pp. 1
–11
.3.
Li
, H. Y.
, Wang
, L. J.
, Jacob
, K.
, and Wong
, C. P.
, 2002
, “Syntheses and Characterizations of Thermally Degradable Epoxy Resins—III
,” J. Polym. Sci. Pol. Chem.
, 40
(11
), pp. 1796
–1807
.4.
Li
, J. H.
, Zhang
, G. P.
, Deng
, L. B.
, Jiang
, K.
, Zhao
, S. F.
, Gao
, Y. J.
, Sun
, R.
, and Wong
, C. P.
, 2015
, “Thermally Reversible and Self-Healing Novolac Epoxy Resins Based on Diels–Alder Chemistry
,” J. Appl. Polym. Sci.
, 132
(26
), p. 42167
.5.
Liu
, W. S.
, Wang
, Z. G.
, Chen
, Z.
, and Zhao
, L. N.
, 2012
, “Thermo-Initiated Cationic Polymerization of Phosphorus-Containing Cycloaliphatic Epoxides With Tunable Degradable Temperature
,” Polym. Degrad. Stab.
, 97
(5
), pp. 810
–815
.6.
Wang
, X.
, and Chung
, D. D. L.
, 1998
, “Short Carbon Fiber Reinforced Epoxy Coating as a Piezoresistive Strain Sensor for Cement Mortar
,” Sens. Actuators, A
, 71
(3
), pp. 208
–212
.7.
Ashrafi
, B.
, Guan
, J.
, Mirjalili
, V.
, Zhang
, Y.
, Chun
, L.
, Hubert
, P.
, Simard
, B.
, Kingston
, C. T.
, Bourne
, O.
, and Johnston
, A.
, 2011
, “Enhancement of Mechanical Performance of Epoxy/Carbon Fiber Laminate Composites Using Single-Walled Carbon Nanotubes
,” Compos. Sci. Technol.
, 71
(13
), pp. 1569
–1578
.8.
Ratna
, D.
, and Banthia
, A. K.
, 2000
, “Epoxidized Soybean Oil Toughened Epoxy Adhesive
,” J. Adhes. Sci. Technol.
, 14
(1
), pp. 15
–25
.9.
Ratna
, D.
, and Banthia
, A. K.
, 2000
, “Toughened Epoxy Adhesive Modified With Acrylate Based Liquid Rubber
,” Polym. Int.
, 49
(3
), pp. 281
–287
.10.
Agrawal
, A.
, and Satapathy
, A.
, 2015
, “Epoxy Composites Filled With Micro-Sized AlN Particles for Microelectronic Applications
,” Part. Sci. Technol.
, 33
(1
), pp. 2
–7
.11.
Liu
, W. S.
, Wang
, Z. G.
, Chen
, Z.
, Li
, J. F.
, and Zhao
, L. N.
, 2012
, “Synthesis and Properties of Two Novel Silicon-Containing Cycloaliphatic Epoxy Resins for Electronic Packaging Application
,” Polym. Adv. Technol.
, 23
(3
), pp. 367
–374
.12.
Liu
, W. S.
, Wang
, Z. G.
, Xiong
, L.
, and Zhao
, L. N.
, 2010
, “Phosphorus-Containing Liquid Cycloaliphatic Epoxy Resins for Reworkable Environment-Friendly Electronic Packaging Materials
,” Polymer
, 51
(21
), pp. 4776
–4783
.13.
Rashid
, E. S. A.
, Ariffin
, K.
, Kooi
, C. C.
, and Akil
, H. M.
, 2009
, “Preparation and Properties of POSS/Epoxy Composites for Electronic Packaging Applications
,” Mater. Des.
, 30
(1
), pp. 1
–8
.14.
Saidina
, D. S.
, Mariatti
, M.
, and Julie
, M. J.
, 2015
, “Dielectric Properties and Thermal Properties of Calcium Copper Titanate and Barium Titanate Hybrid Fillers Filled Epoxy Thin Film Composites for Electronic Packaging Applications
,” J. Mater. Sci. Mater. Electron.
, 26
(8
), pp. 6245
–6251
.15.
Sancaktar
, E.
, and Bai
, L.
, 2011
, “Electrically Conductive Epoxy Adhesives
,” Polymers
, 3
(1
), pp. 427
–466
.16.
Sham
, M. L.
, and Kim
, J. K.
, 2005
, “Curing Behavior and Residual Stresses in Polymeric Resins Used for Encapsulanting Electronic Packages
,” J. Appl. Polym. Sci.
, 96
(1
), pp. 175
–182
.17.
Sun
, X. B.
, Yu
, A. P.
, Ramesh
, P.
, Bekyarova
, E.
, Itkis
, M. E.
, and Haddon
, R.
, 2011
, “Oxidized Graphite Nanoplatelets as an Improved Filler for Thermally Conducting Epoxy-Matrix Composites
,” ASME J. Electron. Packag.
, 133
(2
), p. 020905.18.
Wan
, W. T.
, Yu
, D. M.
, He
, J.
, Xie
, Y. C.
, Huang
, L. B.
, and Gu
, X. S.
, 2008
, “Simultaneously Improved Toughness and Dielectric Proverties of Epoxy/Core-Shell Particle Blends
,” J. Appl. Polym. Sci.
, 107
(2
), pp. 1020
–1028
.19.
Wang
, Z.
, Zhou
, W.
, Dong
, L.
, Sui
, X.
, Cai
, H.
, Zuo
, J.
, and Chen
, Q.
, 2016
, “Dielectric Spectroscopy Characterization of Relaxation Process in Ni/Epoxy Composites
,” J. Alloys Compd.
, 682
, pp. 738
–745
.20.
Zeng
, X. L.
, Ye
, L.
, Guo
, K.
, Sun
, R.
, Xu
, J. B.
, and Wong
, C. P.
, 2016
, “Fibrous Epoxy Substrate With High Thermal Conductivity and Low Dielectric Property for Flexible Electronics
,” Adv. Electron. Mater.
, 2
(5
), p. 1500485
.21.
Agrawal
, A.
, and Satapathy
, A.
, 2014
, “Thermal and Dielectric Behavior of Epoxy Composites Filled With Ceramic Micro Particulates
,” J. Compos. Mater.
, 48
(30
), pp. 3755
–3769
.22.
Singha
, S.
, and Thomas
, M. J.
, 2010
, “Dielectric Properties of Epoxy-Al2O3 Nanocomposite System for Packaging Applications
,” IEEE Trans. Compon. Packag. Technol.
, 33
(2
), pp. 373
–385
.23.
Chen
, C.
, Tang
, Y. J.
, Ye
, Y. S.
, Xue
, Z. G.
, Xue
, Y.
, Xie
, X. L.
, and Mai
, Y. W.
, 2014
, “High-Performance Epoxy/Silica Coated Silver Nanowire Composites as Underfill Material for Electronic Packaging
,” Compos. Sci. Technol.
, 105
, pp. 80
–85
.24.
Du
, F. P.
, Yang
, W.
, Zhang
, F.
, Tang
, C. Y.
, Liu
, S. P.
, Yin
, L.
, and Law
, W. C.
, 2015
, “Enhancing the Heat Transfer Efficiency in Graphene-Epoxy Nanocomposites Using a Magnesium Oxide-Graphene Hybrid Structure
,” ACS Appl. Mater. Interfaces
, 7
(26
), pp. 14397
–14403
.25.
Gonon
, P.
, Sylvestre
, A.
, Teysseyre
, J.
, and Prior
, C.
, 2001
, “Dielectric Properties of Epoxy/Silica Composites Used for Microlectronic Packaging, and Their Dependence on Post-Curing
,” J. Mater. Sci.: Mater. Electron.
, 12
(2
), pp. 81
–86
.26.
Ho
, T. H.
, and Wang
, C. S.
, 2001
, “Modification of Epoxy Resin With Siloxane Containing Phenol Aralkyl Epoxy Resin for Electronic Encapsulation Application
,” Eur. Polym. J.
, 37
(2
), pp. 267
–274
.27.
Jubsilp
, C.
, Takeichi
, T.
, Hiziroglu
, S.
, and Rimdusit
, S.
, 2009
, “Effect of Resin Compositions on Microwave Processing and Thermophysical Properties of Benzoxazine-Epoxy-Phenolic Ternary Systems Filled With Silicon Carbide (SiC) Whisker
,” Polym. Eng. Sci.
, 49
(5
), pp. 1022
–1029
.28.
Khanam
, P. N.
, Al-Maadeed
, M. A.
, and Mrlik
, M.
, 2016
, “Improved Flexible, Controlled Dielectric Constant Material From Recycled LDPE Polymer Composites
,” J. Mater. Sci.: Mater. Electron.
, 27
(8
), pp. 8848
–8855
.29.
Kim
, Y. H.
, Lim
, Y. W.
, Kim
, Y. H.
, and Bae
, B. S.
, 2016
, “Thermally Stable Siloxane Hybrid Matrix With Low Dielectric Loss for Copper-Clad Laminates for High-Frequency Applications
,” ACS Appl. Mater. Interfaces
, 8
(13
), pp. 8335
–8340
.30.
Kong
, L. Q.
, Cheng
, Y. R.
, Jin
, Y. X.
, Qi
, T. K.
, and Xiao
, F.
, 2016
, “Low k Epoxy Resin Containing Cycloaliphatic Hydrocarbon With High Crosslinking Density
,” J. Appl. Polym. Sci.
, 133
(21
), pp. 3456–3465.31.
Lee
, L. H.
, and Chen
, W. C.
, 2005
, “Organic-Inorganic Hybrid Materials From a New Octa(2,3-Epoxypropyl)Silsesquioxane With Diamines
,” Polymer
, 46
(7
), pp. 2163
–2174
.32.
Li
, L.
, and Zheng
, S. X.
, 2016
, “Enhancement of Dielectric Constants of Epoxy Thermosets Via a Fine Dispersion of Barium Titanate Nanoparticles
,” J. Appl. Polym. Sci.
, 133
(16
), pp. 1322–1328.33.
Miao
, X.
, Gui
, D. Y.
, Zeng
, G. F.
, and Liu
, J. H.
, 2010
, “Study on Preparation and Properties of Epoxy Resin Modified by Amine-Terminated Polyimide as Electronic Packaging Materials
,” 11th International Conference on Electronic Packaging Technology and High Density Packaging
(ICEPT-HDP
), Xi'an, China, Aug.16–19, pp. 160–164.34.
Albarran-Preza
, E.
, Corona-Becerril
, D.
, Vigueras-Santiago
, E.
, and Hernandez-Lopez
, S.
, 2016
, “Sweet Polymers: Synthesis and Characterization of Xylitol-Based Epoxidized Linseed Oil Resins
,” Eur. Polym. J.
, 75
, pp. 539
–551
.35.
Chatterjee
, S.
, and Saito
, T.
, 2015
, “Lignin-Derived Advanced Carbon Materials
,” Chemsuschem
, 8
(23
), pp. 3941
–3958
.36.
Duval
, A.
, and Lawoko
, M.
, 2014
, “A Review on Lignin-Based Polymeric, Micro- and Nano-Structured Materials
,” React. Funct. Polym.
, 85
, pp. 78
–96
.37.
Desroches
, M.
, Escouvois
, M.
, Auvergne
, R.
, Caillol
, S.
, and Boutevin
, B.
, 2012
, “From Vegetable Oils to Polyurethanes: Synthetic Routes to Polyols and Main Industrial Products
,” Polym. Rev.
, 52
(1
), pp. 38
–79
.38.
Diaz
, A.
, Katsarava
, R.
, and Puiggali
, J.
, 2014
, “Synthesis, Properties and Applications of Biodegradable Polymers Derived From Diols and Dicarboxylic Acids: From Polyesters to Poly(Ester Amide)s
,” Int. J. Mol. Sci.
, 15
(5
), pp. 7064
–7123
.39.
Li
, C.
, Fan
, H.
, Wang
, D.-Y.
, Hu
, J.
, Wan
, J.
, and Li
, B.
, 2013
, “Novel Silicon-Modified Phenolic Novolacs and Their Biofiber-Reinforced Composites: Preparation, Characterization and Performance
,” Compos. Sci. Technol.
, 87
, pp. 189
–195
.40.
Oliveira
, A.
, Becker
, C. M.
, and Amico
, S. C.
, 2015
, “Evaluation of the Characteristics of an Epoxy Resin With Different Degassing Agents
,” Polimeros
, 25
(2
), pp. 186
–191
. 41.
Lora
, J. H.
, and Glasser
, W. G.
, 2002
, “Recent Industrial Applications of Lignin: A Sustainable Alternative to Nonrenewable Materials
,” J. Polym. Environ.
, 10
(1
), pp. 39
–48
.42.
Sasaki
, C.
, Wanaka
, M.
, Takagi
, H.
, Tamura
, S.
, and Asada
, C.
, 2013
, “Evaluation of Epoxy Resins Synthesized From Steam-Exploded Bamboo Lignin
,” Ind. Crops Prod.
, 43
, pp. 757
–761
.43.
Sun
, G.
, Sun
, H.
, Liu
, Y.
, Zhao
, B.
, Zhu
, N.
, and Hu
, K.
, 2007
, “Comparative Study on the Curing Kinetics and Mechanism of a Lignin-Based-Epoxy/Anhydride Resin System
,” Polymer
, 48
(1
), pp. 330
–337
.44.
Li
, C.
, Dai
, J. Y.
, Liu
, X. Q.
, Jiang
, Y. H.
, Ma
, S. Q.
, and Zhu
, J.
, 2016
, “Green Synthesis of a Bio-Based Epoxy Curing Agent From Isosorbide in Aqueous Condition and Shape Memory Properties Investigation of the Cured Resin
,” Macromol. Chem. Phys.
, 217
(13
), pp. 1439
–1447
.45.
Dai
, J. Y.
, Ma
, S. Q.
, Zhu
, L. X.
, Wang
, S.
, Yang
, L. J.
, Song
, Z. L.
, Liu
, X. Q.
, and Zhu
, J.
, 2016
, “UV-Thermal Dual Cured Anti-Bacterial Thiolene Networks With Superior Performance From Renewable Resources
,” Polymer
, 108
, pp. 215
–222
.Copyright © 2017 by ASME
You do not currently have access to this content.
